About Us

Thanks Bob

On Thu, 29 Apr 2004 10:59:47 -0400, (Bob
D.) wrote:

Dave,

I am far from an expert, but it sounds like you may have a number of problem.

If you're positive you're getting gear oil in the bilge are you also
getting a lot of water? Could be a cracked driveshaft bellows and bad
o-ring(s) on the driveshaft. If there is no water it could be bad
driveshaft o-rings, and perhaps a bad waterpump seal.

I think the only seals you can replace without specialized tools are the
outdrive kit, the water pump base, and those found in the waterpump
housing kit.

I hope this helps.

Bob Dimond

In article , D.B.
wrote:

I have a 1989 Stingray with a 3.0 liter Mercruiser engine with an
Alpha one outdrive. I have been getting about a half a cup of water
in the foot after about every 4 hours of operation. I have been
changing the foot oil after every use (4hours) so as to keep things
from going poop until I could put it in the shop. I recently changed
from the expensive Mercruiser outdrive lube (quicksilver) to a cheaper
80W90 gear oil (seeing as I was changing it after every 4 hours of
operation). I have been noticing what I thought was gear oil in the
bilge, but was not sure until I changed lubes. Now I am positive that
I have gear oil from the foot in the bilge. My question(s) are
these.... would it be that the upper water seals in the outdrive are
causing the water to get into the foot and the oil to leak into the
bilge? Question number two....I am a decent mechanic.....without
having specialized tools, is it practical for me to replace the seals
myself (I did rebuild a Porsche motor several years ago....to give
you a benchmark of my mechanical capabilities)

Any help would be appreciated.

Dave

Thread Tools	Search this Thread
Show Printable Version	Search this Thread: Advanced Search
Display Modes
Switch to Linear Mode Switch to Hybrid Mode Threaded Mode

Similar Threads
Thread	Thread Starter	Forum	Replies	Last Post
Can anyone answer a question I have about lube for a Mercruiser Alpha outdrive foot?	D.B.	General	1	April 22nd 04 10:30 PM
HELP!! I need help with a noisy and whiny Mercruiser outdrive	D.B.	General	7	March 31st 04 12:16 AM
Question about Mercruiser outdrive that is noisy and whines	D.B.	General	0	March 30th 04 02:34 AM
Where to find ramp stories?	designo	General	15	December 9th 03 08:57 PM
flushing question mercruiser alpha 1	jim	General	6	September 27th 03 01:43 AM

Menu

About Us