About Us

Jere Lull wrote in message ...
In article ,
(Chris Butler) wrote:

I just finished winterizing my 2002 1GM10 Yanmar Diesel (that runs on
a Menger 19' Cat boat) and think there must be a better way of
bleeding the fuel system. For the past three seasons I have changed
the water seperator and paper filter on the engine at the end of every
season. Then I begin the huge task of pumping the Raycor water
seperator for the next hour until fuel starts flowing into the engine.
After that I start pumping the lever on the oil pump (1 hour). Once I
get fuel into the lines the rest of the bleeding goes very easy. My
hand afterwards is sore and battered! I have tried cranking the engine
for short bursts with the compression lever up (this does not seem to
help). Is there anyway to prime or help this process along the way?

I think your problem may be that you don't fill the bowl, or have the
wrong Racor. Ours unscrews on top, the filter drops in. I can switch
filters without bleeding. When I do the primary (on the engine), it
takes about 5 minutes to bleed.

Note that there's a third bleed on the high pressure pump (follow the
line after the primary filter). Wasn't mentioned in our owner's guide
and it sometimes is the problem.

If you still have a problem, I "built" primer when I misdiagnosed a
problem: Outboard fuel bulb, hose and male and female fittings to let me
put it in line when I need to move a lot of fuel. Fills the bowl
quickly, then I take it out of line.

I also change filters in the Spring, after running for a while -- to
catch that spring load of critters.

On my old 1GM, I had the same prob till I filled the racor and made
sure all of the lines were full of fuel too. THEN, i got an electric
pump, it makes bleeding the system a breeze. However, it is good to
know you can do it the old way.
The electric pump installs in series with the regular pump between the
racor and the mechanical pump. It was fairly cheap from JC Whitney.

Thread Tools	Search this Thread
Show Printable Version	Search this Thread: Advanced Search
Display Modes
Switch to Linear Mode Switch to Hybrid Mode Threaded Mode

Similar Threads
Thread	Thread Starter	Forum	Replies	Last Post
CARB & FUEL SYSTEM CLEANERS	Coff	General	1	April 6th 04 07:13 AM
Essentials of a Marine Boat Alarm System	Rick Curtis	Electronics	19	February 23rd 04 09:42 AM
ANNOUNCEMENT: Diesel Fuel Decontamination Units Give Stored Fuel Longer Life.	John T. Nightingale	Marketplace	0	February 19th 04 04:48 PM
Fuel System Upgrade	DSK	General	4	February 19th 04 01:11 AM
engine paint in fuel system	David Ward	General	0	August 20th 03 04:20 AM

Menu

About Us