About Us

Mr. Luddite

On 5/12/2014 1:36 PM, wrote:
On Monday, June 28, 2004 3:10:13 PM UTC-5, watertoys wrote:
I've got a '95 Sea Ray 175br with the Mercruiser 3.0LX. After 9 years,
it finally let me down last weekend. Heading back to the campsite at
3200 rpm, the engine stumbled then died. I was able to restart with a
bit of cranking, it idled fine, I got back on plane only to have it
die again after 15-20 seconds. It seemed obvious it was starving for
fuel under power, so I decided the spin-on style fuel filter after the
tank might be clogged. Since I didn't have a spare, I just bypassed it
and ran directy off the tank - the stock setup since I had installed
the extra filter shortly after buying the boat.

The boat ran fine for another 30-35 minutes, then started acting up
again. I decided to just idle back to the campsite, but it eventually
died completely and wouldn't restart. We towed it back with a 3 person
Sea Doo.

The next day I filled the tank. The engine idles fine, but it still
quits after several seconds on plane. The other thing I noticed, is
that I can hear a sucking air sound in the fuel pump vent line. Is
this an obvious sign the pump has gone bad?

I'm going to check the filter in the carb, but it should be pretty
clean given I've run a 2nd screw-on fuel filter just off the tank
since the boat was new. Is there a check valve in the tank that could
be causing trouble?

TIA for any suggestions.

-Karl

Karl,

I have this same problem with my 1997 Crownline 176, with Mercruiser 3.0LX. What did you find was the problem? Seems like possible contamination in the tank or fuel pump issue. Right now mine idles perfect, get up on plane perfect then dies quickly unless I throttle back to less than 3000 rpm. Then I can get maybe 1/4 mile before it dies out.

Thanks,
Bill

I just read this and may not know what I am talking about but you may
have a "nest" built by some creature (bees, wasps or other insect) in
the fuel vent line. That could explain the sucking sound. It could
also explain why the engine is starving for fuel at higher RPMs. Not
enough air getting through the vent line to allow fuel to be pumped do
to causing a partial vacuum.

Don't ask me why I know this. :-)

Similar problem when running an outboard and forgetting to loosen the
vent on the gas tank.

Thread Tools	Search this Thread
Show Printable Version	Search this Thread: Advanced Search
Display Modes
Switch to Linear Mode Switch to Hybrid Mode Threaded Mode

Similar Threads
Thread	Thread Starter	Forum	Replies	Last Post
1976 Merc 850EL engine problem	rufus	General	1	June 7th 04 03:11 AM
Engine dies- Putters when trying to plane- engine under under heavy load	Bora Cider	General	4	May 18th 04 05:12 PM
Diesel Fuel Decontamination Units Give Stored Fuel Longer Life.	John T. Nightingale	General	6	February 20th 04 03:28 PM
Problem With 15 HP Merc	Joe Murdock	General	3	February 17th 04 02:48 PM
fuel delivery problem on outboard? help	Russell Hermansen	General	9	October 7th 03 02:40 AM

Menu

About Us