You don't say whether you operate in fresh or salt water, or whether your
engine has fresh water w/anti-freeze circulating coolant (w/ heat
exchanger). Esp if it's operated in salt water, on a '86 boat, I'd bet on
the riser being clogged. Pull it and have a look -- you'll need new gaskets
when making replacement. You can "rod it out" or have a radiator shop give
it an acid cleaning -- either will give you just one or two seasons more.
Usually better to buy new if you intend to keep the boat.

First choice would have been lower unit pump impeller, but that's fairly
new -- unless it was later run dry and damaged. Impellers should be changed
every three years or so for normal recreational boats. The rubber gets stiff
with age and they lose efficiency. In water with lots of silt and
particulates, esp frequent shallow water operation, they can wear out faster
due to abrasion. Same for the metal contact surface in the pump --
inspection will tell if that (or more likely) the whole pump needs replaced.

Good luck,
Len

Eliminate "ns" for email address.

--
"Mark" wrote in message
sgroups.com...
I have a 350 with an Alpha 1 that is overheating at low rpms. Diagnosing
the same problem last year, I had to have the water pump in the lower unit
replaced. I will troubleshoot all other possibilities this weekend
before
having to pull the boat out, but thought you folks in the news groups may
have some ideas as to what other causes it could be.

The boat is an 86 and I have owned it for about ten years for having to
replace the outdrive water pump. Any estimates as to what the life
expectancy of the water pump should be?

First I will be checking for leaks, then changing the t'stat on the engine
(as I do not recall when I last replaced it), but beyond that, Ican only
suspect either the new (last year) pump has failed prematurely, or the
mechanic I hired to do it did.

Mark (the rail & canopy hook guy)
www.ripnet.com/vtf/prod03.htm