Reply
 
LinkBack Thread Tools Search this Thread Display Modes
  #1   Report Post  
posted to rec.boats
external usenet poster
 
First recorded activity by BoatBanter: Jun 2021
Posts: 1
Default Mercruiser 5.7L Idle Issue

Drove boat to a cove and floated for an hour. When I started it, it started right up and sputtered and stalled when I accelerated. After being towed home, I changed the IAC filter and the boat started and ran fine for several cycles. Then it happened again. It started and ran fine. We floated on the lake and died when we accelerated. It starts but stalls after a few seconds. I changed the IAC valve and it started and ran great until we turned it off and restarted. Same thing. It seems to run and idle fine until we accelerate or rev engine. I am back where I started. Any suggestions of what to try next?
Thank you!
  #2   Report Post  
posted to rec.boats
external usenet poster
 
First recorded activity by BoatBanter: Apr 2021
Posts: 31
Default Mercruiser 5.7L Idle Issue

On 6/14/2021 8:01 AM, Tom Greene wrote:

Drove boat to a cove and floated for an hour. When I started it, it started right up and sputtered and stalled when I accelerated. After being towed home, I changed the IAC filter and the boat started and ran fine for several cycles. Then it happened again. It started and ran fine. We floated on the lake and died when we accelerated. It starts but stalls after a few seconds. I changed the IAC valve and it started and ran great until we turned it off and restarted. Same thing. It seems to run and idle fine until we accelerate or rev engine. I am back where I started. Any suggestions of what to try next?
Thank you!


Just a guess. I had an older 350 ci I/O that exhibited some of your
symptoms. It would start but die under load. Then it stopped running
period.

Turns out it was a bad, leaking coil. It finally blew the connector
right off the top. It would start again but die as soon as I put
it in gear and tried to move. Towed back to the slip and it started
right up again.

Replaced coil. All was fine.


--
This email has been checked for viruses by AVG.
https://www.avg.com

  #3   Report Post  
posted to rec.boats
external usenet poster
 
First recorded activity by BoatBanter: Jul 2007
Posts: 36,387
Default Mercruiser 5.7L Idle Issue

On Mon, 14 Jun 2021 11:59:01 -0400, "Mr. Luddite"
wrote:

On 6/14/2021 8:01 AM, Tom Greene wrote:

Drove boat to a cove and floated for an hour. When I started it, it started right up and sputtered and stalled when I accelerated. After being towed home, I changed the IAC filter and the boat started and ran fine for several cycles. Then it happened again. It started and ran fine. We floated on the lake and died when we accelerated. It starts but stalls after a few seconds. I changed the IAC valve and it started and ran great until we turned it off and restarted. Same thing. It seems to run and idle fine until we accelerate or rev engine. I am back where I started. Any suggestions of what to try next?
Thank you!


Just a guess. I had an older 350 ci I/O that exhibited some of your
symptoms. It would start but die under load. Then it stopped running
period.

Turns out it was a bad, leaking coil. It finally blew the connector
right off the top. It would start again but die as soon as I put
it in gear and tried to move. Towed back to the slip and it started
right up again.

Replaced coil. All was fine.


The fact that he said IAC valve has me thinking this is a new EFI
engine. It probably doesn't have a regular coil.
Is there an OBII2 connector? maybe try scanning for codes.
The problem might be the HP fuel pump. Is there a port to monitor the
rail pressure. That won't usually throw a code.
  #4   Report Post  
posted to rec.boats
external usenet poster
 
First recorded activity by BoatBanter: Jan 2017
Posts: 4,553
Default Mercruiser 5.7L Idle Issue

wrote:
On Mon, 14 Jun 2021 11:59:01 -0400, "Mr. Luddite"
wrote:

On 6/14/2021 8:01 AM, Tom Greene wrote:

Drove boat to a cove and floated for an hour. When I started it, it
started right up and sputtered and stalled when I accelerated. After
being towed home, I changed the IAC filter and the boat started and ran
fine for several cycles. Then it happened again. It started and ran
fine. We floated on the lake and died when we accelerated. It starts
but stalls after a few seconds. I changed the IAC valve and it started
and ran great until we turned it off and restarted. Same thing. It
seems to run and idle fine until we accelerate or rev engine. I am
back where I started. Any suggestions of what to try next?
Thank you!


Just a guess. I had an older 350 ci I/O that exhibited some of your
symptoms. It would start but die under load. Then it stopped running
period.

Turns out it was a bad, leaking coil. It finally blew the connector
right off the top. It would start again but die as soon as I put
it in gear and tried to move. Towed back to the slip and it started
right up again.

Replaced coil. All was fine.


The fact that he said IAC valve has me thinking this is a new EFI
engine. It probably doesn't have a regular coil.
Is there an OBII2 connector? maybe try scanning for codes.
The problem might be the HP fuel pump. Is there a port to monitor the
rail pressure. That won't usually throw a code.


There is a Shrader valve on the rail. The pressure tester is not that
expensive. Should be around 44 psi. Also check the water separator
filter. Since it seems to be heat related, could also be coil.

  #5   Report Post  
posted to rec.boats
external usenet poster
 
First recorded activity by BoatBanter: Dec 2008
Posts: 2,257
Default Mercruiser 5.7L Idle Issue

On Mon, 14 Jun 2021 11:59:01 -0400, "Mr. Luddite" wrote:

On 6/14/2021 8:01 AM, Tom Greene wrote:

Drove boat to a cove and floated for an hour. When I started it, it started right up and sputtered and stalled when I accelerated. After being towed home, I changed the IAC filter and the boat started and ran fine for several cycles. Then it happened again. It started and ran fine. We floated on the lake and died when we accelerated. It starts but stalls after a few seconds. I changed the IAC valve and it started and ran great until we turned it off and restarted. Same thing. It seems to run and idle fine until we accelerate or rev engine. I am back where I started. Any suggestions of what to try next?
Thank you!


Just a guess. I had an older 350 ci I/O that exhibited some of your
symptoms. It would start but die under load. Then it stopped running
period.

Turns out it was a bad, leaking coil. It finally blew the connector
right off the top. It would start again but die as soon as I put
it in gear and tried to move. Towed back to the slip and it started
right up again.

Replaced coil. All was fine.


Sounds like the same symptoms a Moto Guzzi has with a bad coil.
--

Freedom Isn't Free!


  #6   Report Post  
posted to rec.boats
external usenet poster
 
First recorded activity by BoatBanter: Jun 2016
Posts: 4,981
Default Mercruiser 5.7L Idle Issue

On Tue, 15 Jun 2021 07:05:03 -0400, John wrote:

On Mon, 14 Jun 2021 11:59:01 -0400, "Mr. Luddite" wrote:

On 6/14/2021 8:01 AM, Tom Greene wrote:

Drove boat to a cove and floated for an hour. When I started it, it started right up and sputtered and stalled when I accelerated. After being towed home, I changed the IAC filter and the boat started and ran fine for several cycles. Then it happened again. It started and ran fine. We floated on the lake and died when we accelerated. It starts but stalls after a few seconds. I changed the IAC valve and it started and ran great until we turned it off and restarted. Same thing. It seems to run and idle fine until we accelerate or rev engine. I am back where I started. Any suggestions of what to try next?
Thank you!


Just a guess. I had an older 350 ci I/O that exhibited some of your
symptoms. It would start but die under load. Then it stopped running
period.

Turns out it was a bad, leaking coil. It finally blew the connector
right off the top. It would start again but die as soon as I put
it in gear and tried to move. Towed back to the slip and it started
right up again.

Replaced coil. All was fine.


Sounds like the same symptoms a Moto Guzzi has with a bad coil.


Spoofer!
--
Thanks Donald. Do you miss him yet?


----Android NewsGroup Reader----
https://piaohong.s3-us-west-2.amazon...net/index.html
Reply
Thread Tools Search this Thread
Search this Thread:

Advanced Search
Display Modes

Posting Rules

Smilies are On
[IMG] code is Off
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On


Similar Threads
Thread Thread Starter Forum Replies Last Post
3.0 mercruiser issue jbird General 4 September 11th 08 12:44 PM
5.7 Mercruiser Issue In Shallow Water [email protected] General 11 August 12th 06 02:58 AM
Idle [email protected] General 2 July 10th 06 02:12 PM
Omc 350 Won't Run Above Idle Gepetto Boat Building 5 June 24th 05 12:44 PM
Mercruiser won't idle down when warm Jim General 2 August 18th 03 05:42 PM


All times are GMT +1. The time now is 07:41 AM.

Powered by vBulletin® Copyright ©2000 - 2024, Jelsoft Enterprises Ltd.
Copyright ©2004-2024 BoatBanter.com.
The comments are property of their posters.
 

About Us

"It's about Boats"

 

Copyright © 2017