Reply
 
LinkBack Thread Tools Search this Thread Display Modes
  #1   Report Post  
Dick Harper
 
Posts: n/a
Default Mercruiser alternator wire overheating - engine stops - tip

Mercruiser Alternator wire overheating – engine stops - tip

Problem: Engine would stop suddenly at various RPM’s. Low voltage
indicated on dash voltmeter.

Vessel: 1997 Monterey 180, 190HP Mercruiser Vortec V6 I/O, Thunderbolt
ignition.

Electrical system was upgraded to a dual battery system with isolation.
OEM Mando alternator was replaced with Delco alternator since parts and
service were more available and economical.
Deep cycle batteries were used to allow extended use of lights,
entertainment, and electronic equipment.
When the batteries were discharged for about four hours the engine would
occasionally die, without apparent cause. Less than 12 volts was
indicated on the dash voltmeter.
Upon testing it was discovered that when the batteries were partially
discharged the orange wire from the alternator was too hot to touch.
Voltage measured at the batteries was below 12 volts and was often 11
volts. At about 10.6 volts the engine would die.
The alternator output wire was measured and calculated to be 10 gauge.
Charts indicate 10 ga. wire is rated at 22 amps continuous duty.
Alternator output is 55 amps or better.
Alternator output wire was supplemented with 4 ga. wire directly to
battery one. Voltage at battery and on dash increased to at least 13
volts. Orange wire runs cool. Engine ran for two hours continuously
after four hour battery discharge with no problems.

FYI


--
Dick Harper
Please change the "1" to a "-" for a valid reply address.


Reply
Thread Tools Search this Thread
Search this Thread:

Advanced Search
Display Modes

Posting Rules

Smilies are On
[IMG] code is Off
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On


Similar Threads
Thread Thread Starter Forum Replies Last Post
replace head on a mercruiser 350 engine Han General 5 June 18th 04 02:59 AM
power vs sail O:P\) Cruising 36 March 18th 04 03:27 AM
Evinrude FICHT beats out Yamaha in JD Powers survey Billgran General 60 November 4th 03 03:02 PM
Engine News from Genmar Gould 0738 General 8 October 27th 03 05:47 PM
Overheating Yamaha 200 OverHot General 2 October 21st 03 07:24 AM


All times are GMT +1. The time now is 08:28 PM.

Powered by vBulletin® Copyright ©2000 - 2024, Jelsoft Enterprises Ltd.
Copyright ©2004-2024 BoatBanter.com.
The comments are property of their posters.
 

About Us

"It's about Boats"

 

Copyright © 2017